Evaluation of red mud and Mg-Fe spinel as catalysts in the conversion of free fatty acids to biodiesel

Document Type : Original Articles

Authors

Elaheh Kosaripour ¹

Behgam Rahmanivahid ²

Hamed Nayebzadeh ¹

¹ Chemical and Material Engineering Faculty, Esfarayen University of Technology, Esfarayen, North Khorasan, Iran.

² Chemical Engineering Department, Chemical and Material Engineering Faculty, Esfarayen University of Technology, Esfarayen, Iran

10.22067/jmme.2025.92609.1197

Abstract

In the present study, MgFe2O4 spinel synthesized by the combustion method using glycine fuel and red mud obtained from the Jajarm alumina plant were evaluated as two Fe-based catalysts in the esterification process for biodiesel production. To investigate the physico-chemical, and structural characteristics, XRD, FTIR, BET, and FESEM analyses were performed for both samples, and then both samples were used as catalysts in the esterification reaction. The results of the analyses and reactor tests showed that the nano-catalyst synthesized by the combustion method with glycine fuel was very favorable in terms of physical-chemical-structural properties and catalytic performance in the biodiesel production reaction. Under the same reaction conditions, the conversion of the spinel catalyst was 84.6%, while under the same conditions, the conversion rate for red mud was 62.7%. Thus, the red mud and magnesium ferrite spinel (synthesized by the combustion method with glycine fuel) catalysts competed with each other, with the Mg-Fe spinel catalyst performing much more effectively and showing better results compared to the red mud catalyst for the esterification reaction of oleic acid. The results indicated that despite the red mud catalyst being cheaper (a waste product from the aluminum production process), the MgFe2O4 spinel conversion for producing valuable biodiesel fuel was higher. However, it seems that further research is needed for an economic comparison of these two catalysts.

Keywords

Nanostructured catalyst

biodiesel

red mud

ester exchange reaction

MgFe2O4 acetylene

combustion synthesis

Subjects

• Synthesis of Materials

---

References

[1]    K. Ghavami, F. Akhlaghian, and F. Rahmani, "Potassium compounds-Al₂O₃ catalyst synthesized by using the sol-gel urea combustion method for transesterification of sunflower and waste cooking oils," Biomass Conversion and Biorefinery, vol. 12, no. 4, pp. 1139-1152, 2022. https://doi.org/10.1007/s13399-020-00731-z

[2]    S. Ghavami, F. Akhlaghian, S. Mohammadiazar, and F. Rahmani, "Biodiesel production from sunflower and waste cooking oils using KO/RGO catalyst," Environmental Progress & Sustainable Energy, vol. 43, no. 1, p. e14235, 2024. https://doi.org/10.1002/ep.14235

[3]    A. Godarzi, P. Vaziri, F. Akhlaghian, F. Rahmani, and M. and Khaledian, "Innovative magnetic catalyst facilitates biodiesel production via transesterification of sunflower and waste cooking oils," Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, vol. 45, no. 4, pp. 12277-12294, 2023. https://doi.org/10.1080/15567036.2023.2272671

[4]    K. Ghavami, F. Rahmani, and F. Akhlaghian, "Production of Green Fuel Biodiesel from Sunflower Oil Using K₂O Nanoparticles Sonochemically Immobilized over Bentonite," Fuel and Combustion, vol. 13, no. 2, pp. 89-101, 2020.

[5]    F. Akram, H. Aslam, M. Suhail, T. Fatima, and I. ul Haq, "Divulging the future of sustainable energy: Innovations and challenges in algal biodiesel production for green energy," Sustainable Energy Technologies and Assessments, vol. 75, p. 104266, 2025. https://doi.org/10.1016/j.seta.2025.104266

[6]    M. Hassan Pranta and H. Muk Cho, "A comprehensive review of the evolution of biodiesel production technologies," Energy Conversion and Management, vol. 328, p. 119623, 2025. https://doi.org/10.1016/j.enconman.2025.119623

[7]    V. Mandari and S. K. Devarai, "Biodiesel production using homogeneous, heterogeneous, and enzyme catalysts via transesterification and esterification reactions: A critical review," BioEnergy Research, vol. 15, no. 2, pp. 935-961, 2022. https://doi.org/10.1007/s12155-021-10333-w

[8]    I. Riaz et al., "A review on catalysts of biodiesel (methyl esters) production," Catalysis Reviews, vol. 66, no. 4, pp. 1084-1136, 2024. https://doi.org/10.1080/01614940.2022.2108197

[9]    H. Jabbari, "Production of methyl ester biofuel from sunflower oil via transesterification reaction," Asian Journal of Nanosciences and Materials, vol. 1, no. 2, pp. 52-55, 2018.

[10]  N. Anil et al., "Advancements in sustainable biodiesel production: A comprehensive review of bio-waste derived catalysts," Energy Conversion and Management, vol. 318, p. 118884, 2024. https://doi.org/10.1016/j.enconman.2024.118884

[11]  I. S. Abd Manaf et al., "A review for key challenges of the development of biodiesel industry," Energy Conversion and Management, vol. 185, pp. 508-517, 2019. https://doi.org/10.1016/j.enconman.2019.02.019

[12]  A. A. Babadi et al., "Emerging technologies for biodiesel production: processes, challenges, and opportunities," Biomass and Bioenergy, vol. 163, p. 106521, 2022. https://doi.org/10.1016/j.biombioe.2022.106521

[13]  K. Liu, G. Wei, Y. Zhu, L. Zhang, and Z. He, "A clean route of biodiesel production using red mud-based potassium catalyst," Journal of Environmental Chemical Engineering, vol. 11, no. 5, p. 111015, 2023. https://doi.org/10.1016/j.jece.2023.111015

[14]  J. I. Orege et al., "Recent advances in heterogeneous catalysis for green biodiesel production by transesterification," Energy Conversion and Management, vol. 258, p. 115406, 2022. https://doi.org/10.1016/j.enconman.2022.115406

[15]  Q. Liu, R. Xin, C. Li, C. Xu, and J. Yang, "Application of red mud as a basic catalyst for biodiesel production," Journal of Environmental Sciences, vol. 25, no. 4, pp. 823-829, 2013. https://doi.org/10.1016/S1001-0742(12)60067-9

[16]  M. Senthil, K. Visagavel, C. G. Saravanan, and K. Rajendran, "Investigations of red mud as a catalyst in Mahua oil biodiesel production and its engine performance," Fuel Processing Technology, vol. 149, pp. 7-14, 2016. https://doi.org/10.1016/j.fuproc.2016.03.027

[17]  J. Duan et al., "Tailoring nickel precursors on red mud supports for catalytic hydrodeoxygenation of palmitic acid towards green diesel production," Renewable Energy, vol. 241, p. 122279, 2025. https://doi.org/10.1016/j.renene.2024.122279

[18]  M. Almessiere et al., "Electronic, magnetic, and microwave properties of hard/soft nanocomposites based on hexaferrite SrNi0. 02Zr0. 02Fe11. 96O19 with variable spinel phase MFe2O4 (M= Mn, Co, Cu, and Zn)," Ceramics International, vol. 47, no. 24, pp. 35209-35223, 2021. https://doi.org/10.1016/j.ceramint.2021.09.064

[19]  P. Tancredi, P. C. Rivas-Rojas, O. Moscoso-Londoño, D. Muraca, M. Knobel, and L. M. Socolovsky, "Size and doping effects on the improvement of the low-temperature magnetic properties of magnetically aligned cobalt ferrite nanoparticles," Journal of Alloys and Compounds, vol. 894, p. 162432, 2022. https://doi.org/10.1016/j.jallcom.2021.162432

[20]  B. Karmakar and G. Halder, "Accelerated conversion of waste cooking oil into biodiesel by injecting 2-propanol and methanol under superheated conditions: A novel approach," Energy Conversion and Management, vol. 247, p. 114733, 2021. https://doi.org/10.1016/j.enconman.2021.114733

[21]  M. T. Grosmann et al., "Hydrated metal salt pretreatment and alkali catalyzed reactive distillation: A two-step production of waste cooking oil biodiesel," Chemical Engineering and Processing-Process Intensification, vol. 176, p. 108980, 2022. https://doi.org/10.1016/j.cep.2022.108980

[22]  I. Rizwanul Fattah et al., "State of the art of catalysts for biodiesel production," Frontiers in Energy Research, vol. 8, p. 101, 2020. https://doi.org/10.3389/fenrg.2020.00101

[23]  B. Changmai, C. Vanlalveni, A. P. Ingle, R. Bhagat, and S. L. Rokhum, "Widely used catalysts in biodiesel production: a review," RSC advances, vol. 10, no. 68, pp. 41625-41679, 2020. https://doi.org/10.1039/D0RA07931F

[24]  H. Nayebzadeh, F. Naderi, and B. Rahmanivahid, "Assessment the synthesis conditions of separable magnetic spinel nanocatalyst for green fuel production: optimization of transesterification reaction conditions using response surface methodology," Fuel, vol. 271, p. 117595, 2020. https://doi.org/10.1016/j.fuel.2020.117595

[25]  T. Amani, M. Haghighi, and B. Rahmanivahid, "Microwave-assisted combustion design of magnetic Mg–Fe spinel for MgO-based nanocatalyst used in biodiesel production: Influence of heating-approach and fuel ratio," Journal of Industrial and Engineering Chemistry, vol. 80, pp. 43-52, 2019. https://doi.org/10.1016/j.jiec.2019.07.029

[26]  B. Rahmanivahid, M. Pinilla-de Dios, M. Haghighi, and R. Luque, "Mechanochemical synthesis of CuO/MgAl2O4 and MgFe2O4 spinels for vanillin production from isoeugenol and vanillyl alcohol," Molecules, vol. 24, no. 14, p. 2597, 2019. https://doi.org/10.3390/molecules24142597

[27]  B. Rahmanivahid, H. Ajamein, T. Zakizadeh, and H. Nayebzadeh, "Fabrication of super basic BaxMg (1-x) Fe2O4 magnetic spinel nanocatalyst toward biodiesel production," Materials Research Bulletin, vol. 165, p. 112321, 2023. https://doi.org/10.1016/j.materresbull.2023.112321

[28]  H. Nayebzadeh and M. Hojjat, "Fabrication of SO42−/MO–Al2O3–ZrO2 (M= Ca, Mg, Sr, Ba) as Solid Acid–Base Nanocatalyst Used in Trans/Esterification Reaction," Waste and Biomass Valorization, vol. 11, no. 5, pp. 2027-2037, 2020. https://doi.org/10.1007/s12649-018-0526-0